Tribotechnical Properties of the Coatings (Ti-Zr-Nb)N
Analysis of obtaining coatings based on (Ti-Zr-Nb)N by means of vacuum-arc deposition method. Study of their physical and mechanical properties and tribotechnical characteristics. Analysis of chemical composition of elements in the coating (Ti-Zr-Nb)N.
Подобные документы
The coatings based on (Ti-Al-Zr-Nb-Y)N and (Ti-Zr-Hf-V-Nb-Ta)N were obtained by means of vacuumarc deposition from the cathodes in the atmosphere of nitrogen. Their physical and mechanical properties, tribotechnical characteristics have been studied.
статья, добавлен 30.07.2016Structure, composition and properties of these coatings were studied. Hardness measurements and adhesion tests were provided. Values of hardness and cohesive strength. Physical and technological parameters of deposition, elemental composition of coatings.
статья, добавлен 30.07.2016Analysis of the impact of the negative bias potential on the structure, substructure and mechanical properties of ZrN coatings. Analysis of effect of negative potential on the surface morphology during the deposition effect in reducing the droplet phase.
статья, добавлен 23.12.2016Nanocomposite multicomponent coating obtained by vacuum arc deposition method. Analysis of the of the structure of the coating, elemental distribution and composition of the impurity elements using the methods Rutherford backscattering, mass spectrometry.
статья, добавлен 30.07.2016Studding of Deposition of uniform coatings in the vacuum arc deposition setup. A control unit consisted of two electromagnetic coils installed under substrate of 400 mm dia. exposed to the plasma flux at a distance of 325 mm from the plasma duct exit.
статья, добавлен 30.07.2016For ion-plasma coatings of quasi-binary system TiB2-WB2 the influence of composition on structure and adhesion strength has been analyzed. Investigation of ion-plasma coatings in order to determine their adhesive and cohesive strength, scratch resistance.
статья, добавлен 30.07.2016Study of formula for intrinsic stress calculation in coatings deposited from ion flux in the pulse potential mode. The case of deposition of ions with different charges. The critical parameters of pulse potential mode. Stress control deposited coating.
статья, добавлен 30.07.2016Analysis of the deposition temperature of TiC-WC quasi-binary system ion-plasma coatings (magnetron scheme) of different composition. Extension of structural, substructural States in terms of non-equilibrium producing a material of the ion-plasma flows.
статья, добавлен 13.10.2016A widely usage of multicomponent film systems as a sensitive elements - a characteristic feature of multifunctional sensors. Influence of the phase composition, the structure of components on the mechanical properties of three-layer nickel films.
статья, добавлен 30.07.2016Factors that reduce the strength properties of ferromagnetic iron oxides impurities of oxides of stoichiometric composition, etc. Using Mossbauer spectroscopy and x-ray diffraction analysis to determine the effects of magnetic pulses on iron oxides.
статья, добавлен 13.10.2016Acquaintance with the features of the influence of polymer coatings on the lifetime of carriers in silicon crystals used in solar energy. General characteristics of the conditions of magnetic and X-ray exposure, analysis of electrophysical parameters.
статья, добавлен 23.12.2016Physical and mechanical characteristics of the barometric sensor. Rules for designing the oscillating circuit a frequency-dependent device. Criterion of reliability of stable resonator systems. The effects of physical degradation of the air signal.
статья, добавлен 22.12.2016Analysis of the results of irradiation of thin films of zinc selenide 500 nm thick by an electron beam and their deposition by evaporation. Analysis of the optical properties of both irradiated and untouched samples using an ultraviolet spectrophotometer.
статья, добавлен 23.12.2016- 14. Molecular dynamics study of the mechanical properties of the grapheme-like titanium carbide Ti2C
Molecular dynamics simulations have been performed to study the mechanical properties of two-dimensional titanium carbide under tensile deformation. Young modulus was calculated from the linear part of strain-stress curve. The structure of the samples.
статья, добавлен 30.07.2016 Establishing the regularities of the thermal factor and radiation processing influence on the structure of ion-plasma coatings received by magnetron sputtering of quasi-binary WC-TiC system. Creation and use in practice ion-plasma multilayer coatings.
статья, добавлен 30.07.2016The qualitative scheme of the formation of ferromagnetic grains in the matrix with non-magnetic layers of condensation. Analysis of the principle of operation of the automated system for research thermoresistive properties of thin film materials.
статья, добавлен 30.07.2016The receipt of the thermoelectric properties of p-alloy powders and their structural properties. Compaction of powders by vacuum hot pressing and spark plasma sintering. The thermal conductivity of the samples, the calculation of the Seebeck coefficient.
статья, добавлен 13.10.2016Deposition of CuPc under the electric field and without it. The influence of the field on morphological properties. Quantum-chemical modeling and growth mechanisms. The electrical characteristics of the amorphous and crystalline structure of the films.
статья, добавлен 30.07.2016Features of the physical mechanism of hermetic sealing and storing the air cavity of large volume, based on using magnetic fluid. The use of a mechanism for creating devices of sampling and chemical analysis of gases in mines and chemical industry.
статья, добавлен 13.10.2016Analytical comparison of the accuracy of numerical solutions obtained by the FDTD method and the Godunov method in solving telegraph equations. The advantages of the design scheme based on the Godunov method in the analysis of dynamic modes in long lines.
статья, добавлен 02.02.2019- 21. Fractal Continual Model of Matter for Classification of Nanostructures, Clusters and Massive Bodies
Study of physical-chemical properties of the clusters. The fractal conception of the essence of the a theory of vibrations of crystal lattices and the resulting thermodynamics of solids. Investigation of the optimal heat capacity of nanostructures.
статья, добавлен 30.07.2016 Analysis of the possibility of changing the absorption spectra of photocatalytic nanopowders TiO2 to increase the efficiency of the reaction. Development of original nanotechnology deposition of Ni-B clusters on the surface of nanoparticles of powders.
статья, добавлен 21.06.2018Unique size and morphologydependent physical and chemical properties - some of the specific features of nanoscale metal oxide materials. Determination of the gas response and selectivity to hydrogen. Zinc oxide like a wide band gap semiconductor.
статья, добавлен 30.07.2016The study of the basic properties of the interfaces between the substrates and high-temperature superconductors of films. Characteristics of the surface resistance of the film at microwave frequencies. Improving the microwave properties of the HTS film.
статья, добавлен 28.10.2018Preparation and study of a metal-component nanocomposite system with ferromagnetic inclusions. Coefficients of composite layers in free space were calculated as a function of the content of ferromagnetic inclusions and the thickness of the layer.
статья, добавлен 29.01.2017